|本期目录/Table of Contents|

[1]丁松,陈虹月,徐超,等.改性活性炭对羽毛水解液中芳香族氨基酸的吸附[J].南京工业大学学报(自然科学版),2019,41(03):311-317.[doi:10.3969/j.issn.1671-7627.2019.03.007]
 DING Song,CHEN Hongyue,XU Chao,et al.Adsorption of aromatic amino acids in feather hydrolysate by modified activated carbon[J].Journal of NANJING TECH UNIVERSITY(NATURAL SCIENCE EDITION),2019,41(03):311-317.[doi:10.3969/j.issn.1671-7627.2019.03.007]
点击复制

改性活性炭对羽毛水解液中芳香族氨基酸的吸附()
分享到:

《南京工业大学学报(自然科学版)》[ISSN:1671-7627/CN:32-1670/N]

卷:
41
期数:
2019年03期
页码:
311-317
栏目:
出版日期:
2019-05-28

文章信息/Info

Title:
Adsorption of aromatic amino acids in feather hydrolysate by modified activated carbon
文章编号:
1671-7627(2019)03-0311-07
作者:
丁松陈虹月徐超孙阳胡燚
南京工业大学 药学院,江苏 南京 211800
Author(s):
DING SongCHEN HongyueXU ChaoSUN YangHU Yi
College of Pharmacy, Nanjing Tech University,Nanjing 211800,China
关键词:
改性活性炭 芳香族氨基酸 羽毛水解液
Keywords:
modified ctivated carbon aromatic amino acids feather hydrolyzate
分类号:
TS201.1
DOI:
10.3969/j.issn.1671-7627.2019.03.007
文献标志码:
A
摘要:
本文首先对吸附羽毛水解液中芳香族氨基酸(AA)的活性炭进行筛选,然后对筛选出的活性炭进行酸碱改性。在考察的杏壳、椰壳、果壳、木质和煤质活性炭中,杏壳活性炭对AA吸附、洗脱效果最佳。实验表明:碱改性后的活性炭吸附效果较好,经碱改性的杏壳活性炭的比表面积、总孔容、微孔容均增大,酸改性则相反。Boehm滴定和傅里叶红外光谱(FT-IR)表征结果表明:碱改性后含氧官能团比未改性活性炭大幅减少,酸改性则明显增加。通过单因素试验确定NaOH改性杏壳活性炭对AA的静态吸附-洗脱工艺优化条件:上样液pH为5.6、上样液中酪氨酸质量浓度为2.4 mg/mL、乙醇体积分数为60%。NaOH改性的杏壳活性炭对AA的动态吸附-洗脱工艺优化条件:上样量为320 mL、上样流速为2 mL/min、洗脱流速为1.5 mL/min、洗脱体积为660 mL。在优化条件下,酪氨酸和苯丙氨酸回收率分别为76.3%和73.9%,纯度分别为81.7%和82.9%,表明NaOH改性的杏壳活性炭对羽毛水解液中芳香族氨基酸具有良好的分离纯化效果。
Abstract:
Activated carbons for aromatic amino acids(AA)in feather hydrolysate was screened, and activated carbons were modified by acid-base solutions. Among five kinds of activated carbons(apricot shell, coconut shell, fruit shell, wood and coal)investigated, the activated carbon from apricot shell had the best AA adsorption and desorption. Results showed that the alkali modified activated carbon, with the increase in the surface area, the total pore volume and micropore volume, had better AA adsorption performance than that on the acid modified one. Boehm titration and Fourier transform infrared spectroscopy(FT-IR)showed that the content of acidic oxygenated function groups was significantly decreased with the alkali modified activated carbon, but was significantly increased with the acid modification. The optimum parameters for the static adsorption-desorption of AA on NaOH-modified apricot shell activated carbon were determined by single factor experiments with the concentration of 2.4 mg/mL, pH of 5.6, and desorption solvent of 60% ethanol. The best purification parameters optimized by dynamic adsorption and desorption tests were as follows: the sample loading amount of 320 mL, flow rate of 2 mL/min, and subsequent elution with an eluent volume of 660 mL at 1.5 mL/min flow rate. Under such conditions, the recoveries of tyrosine and phenylalanine were 76.3% and 73.9%, the purity of tyrosine and phenylalanine were 81.7% and 82.9% respectively, indicating that NaOH-modified apricot shell activated carbon had a good adsorption of aromatic amino acids in feather hydrolysate.

参考文献/References:

[1] TITUS E,KALKAR A K,GAIKAR V G.Equilibrium studies of adsorption of amino acids on NaZSM-5 zeolite[J].Colloids & Surfaces A(Physicochemical & Engineering Aspects),2003,223(1/2/3):55.
[2] GOSCIANSKA J,OLEJNIK A,PIETRZAK R.Adsorption of L-phenylalanine onto mesoporous silica[J].Materials Chemistry & Physics,2013,142(2/3):586.
[3] PIAO L,LIU Q,LI Y,et al.Adsorption of L-phenylalanine on single-walled carbon nanotubes[J].The Journal of Physical Chemistry C,2008,112(8):2857.
[4] MAHANINIA M H,RAHIMIAN P,KAGHAZCHI T.Modified activated carbons with amino groups and their copper adsorption properties in aqueous solution[J].Chinese Journal of Chemical Engineering,2015,23(1):50.
[5] MARTÍNEZ F,PARIENTE I,BREBOU C,et al.Chemical surface modified-activated carbon cloth for catalytic wet peroxide oxidation of phenol[J].Journal of Chemical Technology and Biotechnology,2014,89(8):1182.
[6] KIM K J,KANG C S,YOU Y J,et al.Adsorption-desorption characteristics of VOCs over impregnated activated carbons[J].Catalysis Today,2006,111(3/4):223.
[7] LI L,LIU S,LIU J.Surface modification of coconut shell based activated carbon for the improvement of hydrophobic VOC removal[J].Journal of Hazardous Materials,2011,192(2): 683.
[8] 文勇,伍海涛,李伟荣,等.HPLC法同时测定不同厂家珍珠明目滴眼液中17种氨基酸的含量[J].中药新药与临床药理,2017(3):372.
[9] 刘寒冰,杨兵,薛南冬.酸碱改性活性炭及其对甲苯吸附的影响[J].环境科学,2016,37(9):3670.
[10] TSAI J H,CHIANG H M,HUANG G Y,et al.Adsorption characteristics of acetone,chloroform and acetonitrile on sludge-derived adsorbent,commercial granular activated carbon and activated carbon fibers[J].Journal of Hazardous Materials,2008,154(1/2/3):1183.
[11] KURDI J,TREMBLAY A Y.The determination of interaction parameters in the characterization of polyetherimide gas separation membranes using the Horvath-Kawazoe model[J].Desalination,2002,148(1):341.
[12] BOEHM H P.Chemical identification of surface groups[J].Advances in Catalysis,1966,16:179.
[13] 简相坤,刘石彩.活性炭微结构与吸附、解吸CO2的关系[J].煤炭学报,2013,38(2):326.
[14] DAIFULLAH A A M,GIRGIS B S.Impact of surface characteristics of activated carbon on adsorption of BTEX[J].Colloids and Surfaces A(Physicochemical and Engineering Aspects),2003,214(1/2/3):181.
[15] 杨颖,李磊,孙振亚,等.活性炭表面官能团的氧化改性及其吸附机理的研究[J].科学技术与工程,2012,12(24):6132.
[16] LIU Y,LI Z,SHEN W.Surface chemical functional groups modification of porous carbon[J].Recent Patents on Chemical Engineering,2008,1(1):27.
[17] LASZLO K,JOSEPOVITS K,TOMBACZ E.Analysis of active sites on synthetic carbon surfaces by various methods[J].Analytical Sciences,2001,17:i1741.
[18] 范延臻,王宝贞.改性活性炭对有机物的吸附性能[J].环境化学,2001,20(5):444.
[19] 张业辉.蔗梢中氨基酸的提取分离研究[D].南宁:广西大学,2007:36.
[20] 陈瑞锋,陈璐,陈廷登.用活性炭分离纯化苯丙氨酸与酪氨酸的研究[J].浙江工业大学学报(工学版),2006(4):34373.
[21] 吕春茂,宋雨涵,孟宪军,等.大孔树脂纯化寒富苹果渣多酚工艺优化[J].食品工业科技,2012,33(6):300.
[22] 孙卫东,张业辉,朱蓉艳,等.从甘蔗梢中提取氨基酸的方法:CN102260181A[P].2011-11-30.
[23] 刘长江,栾云峰,王菲,等.大孔吸附树脂分离纯化软枣猕猴桃总黄酮[J].食品科学,2011,32(12):145.
[24] 董琦,高珊,曹龙奎.大孔树脂纯化桦褐孔菌多酚及其成分分析[J].食品科学,2015,36(22):131.
[25] 李斌,高凝轩,刘辉,等.大孔树脂纯化黑果腺肋花楸多酚的工艺优化[J].食品科学,2016,37(16):69.

备注/Memo

备注/Memo:
收稿日期:2018-02-07
基金项目:国家自然科学基金(21676143); 青蓝工程; 江苏高等学校优秀科技创新团队计划
作者简介:丁松(1992—),男,E-mail:shanerain1992@outlook.com; 胡燚(联系人),教授,E-mail:huyi@njtech.edu.cn.
引用本文:丁松,陈虹月,徐超,等.改性活性炭对羽毛水解液中芳香族氨基酸的吸附[J].南京工业大学学报(自然科学版),2019,41(3):311-317..
更新日期/Last Update: 2019-05-30