|本期目录/Table of Contents|

[1]刘应磊,潘勇,唐荣坚,等.二元可燃烃类混合气体的爆炸下限实验及理论预测[J].南京工业大学学报(自然科学版),2019,41(02):212-217.[doi:10.3969/j.issn.1671-7627.2019.02.013]
 LIU Yinglei,PAN Yong,TANG Rongjian,et al.Experiments and theoretical prediction of lower explosion limit for binary flammable hydrocarbon gas mixtures[J].Journal of NANJING TECH UNIVERSITY(NATURAL SCIENCE EDITION),2019,41(02):212-217.[doi:10.3969/j.issn.1671-7627.2019.02.013]
点击复制

二元可燃烃类混合气体的爆炸下限实验及理论预测()
分享到:

《南京工业大学学报(自然科学版)》[ISSN:1671-7627/CN:32-1670/N]

卷:
41
期数:
2019年02期
页码:
212-217
栏目:
出版日期:
2019-03-19

文章信息/Info

Title:
Experiments and theoretical prediction of lower explosion limit for binary flammable hydrocarbon gas mixtures
文章编号:
1671-7627(2019)02-0212-06
作者:
刘应磊潘勇唐荣坚杨黎王玉宾蒋军成
南京工业大学 安全科学与工程学院,江苏 南京 210009
Author(s):
LIU YingleiPAN YongTANG RongjianYANG LiWANG YubinJIANG Juncheng
College of Safety Science and Engineering,Nanjing Tech University,Nanjing 210009,China
关键词:
爆炸下限 二元可燃烃类混合气体 实验 Chemkin模拟
Keywords:
lower explosive limit binary flammable hydrocarbon gas mixture experiment Chemkin simulation
分类号:
TQ016
DOI:
10.3969/j.issn.1671-7627.2019.02.013
文献标志码:
A
摘要:
利用FRTA爆炸极限测试仪对二元可燃烃类混合气体爆炸下限(LEL)进行测试,共获得16组144个二元可燃混合气体的爆炸下限值,并对混合气体随其组分及配比变化的规律进行研究。基于Chemkin软件的绝热燃烧相平衡模型模拟了二元可燃烃类混合气体的绝热燃烧过程,以绝热压升达到324.24 kPa为依据判断此时可燃混合气体已达爆炸下限。结果表明:模拟规律与实验规律相类似,且两者间曲线变化幅度差距不大; 样本中二元可燃混合气体爆炸下限预测值与实验值平均绝对误差为0.22%,平均相对误差为9.41%,预测误差在实验误差允许范围之内,可见预测方法具有较强的可靠性。本文的研究为工程上预测二元可燃混合气体的爆炸下限提供了一种新的有效方法。
Abstract:
The explosion limit are an important parameter to evaluate explosive characteristic of combustible,and is applied in the combustible gas monitoring and early warning and risk assessment.16 group with 144 lower explosion limit(LEL)values of binary flammable hydrocarbon gas mixtures were tested by FRTA explosion limit tester and its variation with the gas mixture compositions and ratios were investigated.Based on the adiabatic combustion phase equilibrium of Chemkin model,the adiabatic combustion process of binary combustible hydrocarbon gas mixtures was simulated.The combustible gas mixtures reached their lower explosive limits at the time when adiabatic pressure increased to 324.24 kPa. It was found that the simulation values were similar to the experimental results,and the curve variation between gap was not obvious,average absolute error was 0.22%(volume fraction),and the average relative error was 9.41% with the prediction error in the acceptable range.The prediction was reliable by Chemkin for lower explosion limit of binary combustible gas mixtures,and it provided a new effective way for the engineering prediction of lower explosive limit for binary flammable hydrocarbon gas mixtures.

参考文献/References:

[1] KEE R J,RUPLEY F M,MEEKS E,et al.Chemkin-III:a fortran chemical kinetics package for the analysis of gas-phase chemical and plasma kinetics[J].Office of Scientific & Technical Information Technical Reports,2010,96:101.
[2] YE L T,PAN Y,JIANG J C,et al.A numerical study of the auto-ignition temperatures of CH4-air,C3H8-air,CH4-C3H8-air and CH4-CO2-air mixtures[J].Journal of Loss Prevention in the Process Industries,2014,29:85.
[3] 吴松林,杜扬,李国庆,等.C1~C4烷烃混合气体热爆燃的简化机理与分析[J].爆炸与冲击,2015,35(5):641.
[4] 董刚,蒋勇,陈义良,等.大型气相化学动力学软件包Chemkin及其在燃烧中的应用[J].火灾科学,2000,9(1):27.
[5] ZAJEMSKA M,MUSIAL D,POSKART A.Application of Chemkin and Comsol programs in the calculations of chemical composition of natural gas combustion products[J].Combustion Science and Technology,2014,186(2):153.
[6] MARINOV N,PITZ W,WESTBROOK C,et al.Aromatic and polycyclic aromatic hydrocarbon formation in a laminar premixed n-butane flame[J].Combustion and Flame,1998,114(1/2):192.
[7] NORMAN F,VAN DEN SCHOOR F,VERPLAETSEN F.Auto-ignition and upper explosion limit of rich propane-air mixtures at elevated pressures[J].Journal of Hazardous Materials,2006,137(2):666.
[8] 田贯三,李兴泉.城镇燃气爆炸极限影响因素与计算误差的分析[J].中国安全科学学报,2002,12(6):48.
[9] VAN DEN SCHOOR F,VERPLAETSEN F.The upper explosion limit of alkanes and alkenes in air at elevated pressures and temperatures [J].Hazardous Materials,2006,128:1.
[10] American Society for Testing and Materials.Standard test method or concentration limits of flammability of chemicals(vapors and gases):ASTM E681-2009 [S].Philadelphia:ASTM,2009.
[11] 杨鹏,潘勇,将军成,等.基于Chemkin的可燃气体爆炸下限模拟研究[J].消防科学与技术,2016,35(11):1525.

备注/Memo

备注/Memo:
收稿日期:2017-05-16
基金项目:国家自然科学基金(21576136,21436006)
作者简介:刘应磊(1996—),男,E-mail: 847069877@qq.com; 潘勇(联系人),教授,E-mail:yongpannjut@163.com.
引用本文:刘应磊,潘勇,唐荣坚,等.二元可燃烃类混合气体的爆炸下限实验及理论预测[J].南京工业大学学报(自然科学版),2019,41(2):212-217..
更新日期/Last Update: 2019-03-31